Technical Support

Rotax engines with Nippon Denso
CDI Ignition

Page 1 INTRODUCTION
Page 2 TROUBLE SHOOTING
Page 3 PROCEDURES FOR CHECKING SYSTEM
Page 4 CAUSES AND SYMPTOMS OF TROUBLE
Page 5 PARTS INSPECTION PROCEDURES




Rotax engines with Nippon Denso CDI Ignition
Trouble shooting - Page 4 - Page 6

2-3 CAUSES AND SYMPTOMS OF TROUBLE

Flywheel and Generator

 


Symptom  Cause

Flywheel Generator

Ignition coil

Low speed charging coil

High speed charging coil

Lighting coil

Primary winding

Secondary winding

Engine does not start

Winding open

Winding open

 

Winding open or layer short

Winding open or layer short

Engine stalls at low speed

Winding layer short

 

 

 

 

Irregularity at low speed

Winding layer short

 

 

Winding layer short

Winding layer short

Irregularity at high speed

 

Winding layer short

 

 

Winding layer short

Load is not charged

 

 

Winding open

 

 


[Note]

If engine does not start or stop, check the engine stop switch before these inspections.
If defective conditions are not found by these inspections, check the control unit internal circuit.



If you have any information you would like to see added here,

please send us an email Support@aircommander.com

 



Fighter Pilot Hunter drove the
craft very well after a quick
lesson.Veiw a Quick Clip
featuring Air Commander
Hovercraft.
 Copyright © 2000 [Air Commander Hovercraft] All rights reserved.
 

Home | About | Contact